Recalls (7)
Engine and engine cooling — EngineCampaign 14E007000 · 07 Mar 2014Problem: The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Risk: A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Exterior lighting — HeadlightsCampaign 09E025000 · 11 May 2009Problem: Dope, inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Risk: Decreased lighting visibility may result in a vehicle crash.
Remedy: Dope, inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on july 28, 2009. Owners may contact dope, inc. At 1-626-272-1798.
Exterior lightingCampaign 09E012000 · 07 Apr 2009Problem: Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Risk: Decreased lighting visibility may result in a vehicle crash.
Remedy: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.
Service brakes, hydraulic — Master cylinderCampaign 07E023000 · 29 Mar 2007Problem: Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. The seal on master cylinder can fail and leak brake fluid.
Risk: Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Remedy: Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during april 2007. Owners can contact cardone at 1-800-777-4780.
Exterior lighting — SwitchCampaign 07V063000 · 20 Feb 2007Problem: On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.
Risk: The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.
Remedy: Dealers will install the newly designed brake light switch free of charge. The recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the vin number of the vehicle. Owners may contact vw at 1-800-822-8987.
Exterior lighting — SwitchCampaign 04V584000 · 16 Dec 2004Problem: On certain passenger vehicles, the hazard switch and flasher system function may degrade over time because of distortion and material transfer of the contacts of certain hazard switch relays which occurs due to substantially increased electrical current load from higher wattage turn signal bulbs.
Risk: This may result in intermittent or inoperative turn signal and hazard flasher function.
Remedy: Dealers will replace the hazard flasher switch/relay kit. The recall began on march 31, 2005. Owners should contact volkswagen at 1-800-822-8987.
Service brakes, hydraulic — Antilock/traction control/electronic limited slipCampaign 02V031000 · 31 Jan 2002Problem: On some passenger vehicles, short circuits can occur within the electronic control unit of the anti-lock braking system (abs).
Risk: This can result in a fire.
Remedy: Dealers will replace the abs control unit. Owner notification began march 8, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-8987.