Recalls (6)
Air bags — FrontalCampaign 21V800000 · 14 Oct 2021Problem: Volvo Cars USA, LLC (Volvo Car) is recalling certain 2001-2007 V70 and XC70 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed December 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10136.
Equipment — Navigational system(global positioning system)Campaign 10V566000 · 08 Nov 2010Problem: Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
Risk: An overheated battery could lead to a fire.
Remedy: Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.
Fuel system, gasoline — Fuel pumpCampaign 09V483000 · 18 Dec 2009Problem: Volvo is recalling certain model year 2001-2005 s80, model year 2001-2004 v70, s60, xc70 and model year 2003-2005 xc90 vehicles sold in or registered in the states of alabama, arizona, arkansas, california, florida, georgia, hawaii, kentucky, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, utah, virginia and the u.s. Territories. When exposed to certain environmental conditions (hot climate and temperature cycling) over time and in combination with varying fuel quality, the fuel pump can develop cracks in the fuel pump flange.
Risk: If the condition occurs vehicle owners may notice fuel smell and/or fuel leak which, in the presence of an ignition source, could result in a fire.
Remedy: Dealers will inspect the fuel pump installed in the vehicle, and if necessary replace the fuel pump with a part of a modified design. This service will be performed free of charge. The safety recall began on january 15, 2010. Owners may contact volvo at 1-800-458-1552.
Engine and engine coolingCampaign 07V226000 · 05 Jun 2007Problem: On certain passenger vehicles, the fuel pressure sensor located on the left end of the fuel rail may, at times, transmit incorrect signal regarding the fuel pressure to the engine control module. If the signal is outside of the pre-programmed allowable limits, a diagnostic trouble code may be set and the check engine light will come on. The soldered joints on the circuit board of the fuel pressure sensor may crack due to temperature changes and excessive vibrations.
Risk: Misfire may occur during driving that, in turn, will reduce the engine torque and in the worst case scenario, the engine may stall without warning. In certain traffic situations this could cause an unsafe situation and possibly a crash.
Remedy: Dealers will replace the fuel pressure sensor free of charge. The recall began on june 29, 2007. Owners may contact volvo at 1-800-458-1552.
Service brakes, hydraulic — Master cylinderCampaign 07E023000 · 29 Mar 2007Problem: Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. The seal on master cylinder can fail and leak brake fluid.
Risk: Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Remedy: Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during april 2007. Owners can contact cardone at 1-800-777-4780.
Steering — LinkagesCampaign 04V029000 · 16 Jan 2004Problem: On certain passenger vehicles, the front control arms may not have been manufactured correctly and, as a result, the stud and nut that secure the arm to the spindle may lose their initial axial tension. Under certain driving conditions, the steering may become less responsive and the driver may experience steering wheel play.
Risk: This driving condition could eventually lead to separation between the front control arm and the spindle, which could result in a crash.
Remedy: Dealers will install a new type of nut. Owner notification began on february 16, 2004. Owners should contact volvo cars at 1-800-458-1552.