NHTSA lists 3 recalls for the 2004 Volvo V40; the most frequently affected component is service brakes, hydraulic — hoses, lines/piping, and fittings. Owners filed 4 complaints, most often about service brakes. Among the 5 model years of this model in the database, 2004 ranks #1 for number of recalls.
Problem: On certain passenger vehicles, the non-return valve may crack due to a poor weld causing a vacuum leak.
Risk: If this occurs, more brake pedal force may be required to stop the vehicle and/or may experience a rough engine idle, which could result in a crash.
Remedy: Dealers will inspect, and if necessary, replace the vacuum hose. The recall began on november 29, 2004. Owners should contact volvo cars at 1-800-458-1552.
Problem: On certain sedans and station wagons, there may be a fuel leak from the fuel rail due to inadequate welding.
Risk: Fuel leakage in the presence of an ignition source could result in a fire.
Remedy: Dealers will install a v-clamp to the fuel rail. Owner notification began on january 28, 2004. Owners should contact volvo at 1-800-458-1552.
Problem: Certain passenger cars fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems." the second isofix guide was not installed in these vehicles and, in certain cases, the owner's manual isofix information is incorrect.
Risk: This does not meet the requirements of the standard.
Remedy: Owners will receive a letter/package consisting of the second isofix guide with installation instructions, and in certain cases, the corrected owner's manual may be provided. If the owner wants to take their vehicle to a volvo dealer for installation of the guide, it will be performed at no charge to the owner. Owner notification began on december 19, 2003. Owners should contact volvo at 1-800-458-1552.
Share of the 4 most recent complaints stored for this model year, by component. Owners can list more than one component.
Dt: consumer states when there is a sun glare on the dashboard there isn't enough illumination. The consumer was unable to see the instruments on the dashboard. The consumer took the vehicle to the dealership and was told there was nothing that could be done about it.*ak the consumer stated a flash light must be used…
Tl* the contact owns a 2004 volvo v40. While driving 15 mph, the brakes malfunctioned. The contact depressed the brake pedal to the floorboard in order to stop the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the issue. The failure mileage was 44,000.
On april 13, 2005 at approximately 4 pm, i was backing my v40 volvo 2004 wagon out of a parking space at the kossman garage, liberty avenue,pittsburgh, pa, going slowly because it was a tight space, when my brakes did not work, at all. Despite pushing my brakes as far as they would go, the car did not stop, and…
The driver's side airbag has failed for no apparent reason. The cost of repair will be around $900.00 the car was purchased 4 years ago. That is a very costly repair for a relatively young vehicle. I asked the service representative at my authorized volvo repair shop if i should expect the right side to fail as soon…
Recalls per model year for this model.
Recall and complaint records from the US National Highway Traffic Safety Administration (NHTSA). A recall listed here may not apply to every vehicle of this model year — always check your VIN with NHTSA or a dealer.