NHTSA lists 3 recalls for the 2009 Volvo S40 FWD; the most frequently affected component is seats. Owners filed 10 complaints, most often about power train. Among the 12 model years of this model in the database, 2009 ranks #4 for number of recalls.
Problem: Volvo is recalling certain passenger vehicles equipped with power front passenger seats. The front seat rail's detection system was manufactured incorrectly and may permit the passenger to forward the seat beyond the intended maximum.
Risk: Positioning of the seat beyond the intended maximum can cause increased risk of injury to the passenger in the event of a crash.
Remedy: Dealers will inspect the front power seat stops for both front seats for the presence of an "end stop" and repair the vehicles as necessary free of charge. The safety recall began on december 23, 2010. Owners may contact volvo at 1-800-458-1552 or at customercare@volvoforlife.com.
Problem: Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
Risk: An overheated battery could lead to a fire.
Remedy: Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.
Problem: Volvo is recalling my 2008-2009 vehicles. A section of the power steering return line hose was not properly vulcanized (cured) and does not meet specifications. If the power steering return hose fails, a sudden rupture of the hose can occur.
Risk: This can result in a rapid drainage of the power steering fluid in the system and a complete loss of power assistance, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the steering return line hose assembly free of charge. The recall began on august 13, 2008. Owners may contact volvo at 1-800-458-1552.
What owners complain about
Share of the 10 most recent complaints stored for this model year, by component. Owners can list more than one component.
Power train3 · 30%
Unknown or other2 · 20%
Electrical system1 · 10%
Exterior lighting1 · 10%
Service brakes1 · 10%
Hydraulic1 · 10%
Engine1 · 10%
Suspension1 · 10%
When complaints were filed
20091
20131
20142
20151
20161
20171
20182
20211
From owner complaints
Replacement of cv joints- october 2018 my vehicle was diagnosed with leakage from the cv joints which splattered all underneath my vehicle. My vehicle only had 69,000 miles. The technician stated that they should not have been a problems with so few miles. He stated that my vehicle's steering would have been…
Headlight wiring- made an attempt to change light bulbs for headlamps. Covering around electrical wiring harness which connect to headlight crumbled in my hands and electrical wiring is exposed. Worries that this may be potential fire hazard to my vehicle and myself. My vehicle was stationary in my driveway.
Tl* the contact owns a 2009 volvo s40. While driving approximately 25 mph, the accelerator pedal was depressed, but the vehicle failed to accelerate. The vehicle independently decelerated and stalled. The vehicle was towed to a dealer where it was diagnosed that the transmission fuel line was fractured. The…
New 2009 volvo s40 sedan brake fire 1. Vehicle was driven 3 miles from a high school parking lot to the owner's home. 2. There was a fire between the brake pad and the rotor in the rear passenger side wheel well. 3. The rotor, brake caliper and brake pads were replaced. *tr
Recall and complaint records from the US National Highway Traffic Safety Administration (NHTSA). A recall listed here may not apply to every vehicle of this model year — always check your VIN with NHTSA or a dealer.