Recalls (6)
Steering — ColumnCampaign 10V554000 · 11 Nov 2010Problem: Nissan is recalling certain model year 2002-2004 frontier vehicles manufactured from july 9, 2001 through october 20, 2004, and model year 2002-2004, xterra vehicles manufactured from july 9, 2001, through january 6, 2005. Over time corrosion may form in the lower steering column joint and limit movement of the joint. The limited movement of this joint may create excessive load on the lower steering column shaft. If the vehicle continues to be driven in this condition, it may lead to cracking of the shaft during low speed maneuvers that require large steering inputs.
Risk: The shaft may break which could result in loss of steering control during these low speed maneuvers increasing the risk of a crash.
Remedy: The steering column shaft and joint will be replaced with a shaft of a different design. This service will be performed free of charge. The recall began on december 13, 2010. Owners may contact nissan at 1-800-647-7261.
Exterior lightingCampaign 06E026000 · 23 Mar 2006Problem: Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Risk: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Remedy: Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on april 3, 2006. Owners may contact pro-a motors at 323-838-2988.
Fuel system, gasoline — Fuel pumpCampaign 04V230000 · 24 May 2004Problem: On certain pickup trucks equipped with six cylinder engines and sport utility vehicles equipped with four or six cylinder engines, the fuel pump terminal on the fuel-sending unit can develop a crack in the plastic molding. This can cause the terminal strip to corrode under some environmental conditions.
Risk: If corrosion occurs, the terminal strip could eventually break causing the fuel pump to stop operation. This will result in not being able to start the engine or cause the engine to stop running without warning, which can result in a crash.
Remedy: In the following states, dealers will replace the fuel-sending unit. These states are connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, tennessee, vermont, virginia, west virginia, wisconsin, and the district of columbia. In the other states, the dealer will inspect the fuel pump terminal on the sending unit for corrosion. If corrosion is present, the dealer will replace the unit. If there is not corrosion, the dealer will apply sealant to the terminal housing to help prevent corrosion in the future. Owner notification began on june 28, 2004. Owners should contact nissan at 1-800-647-7261.
Air bags — Inflator moduleCampaign 03V061000 · 27 Feb 2003Problem: On certain vehicles, the electrical connector for the driver air bag may come loose. If the connector comes loose, the supplemental air bag warning light flashes intermittently.
Risk: The driver side air bag will not deploy in the event of a crash, increasing the risk of personal injury.
Remedy: Dealers will install a retaining clip on the clock spring electrical connector. Owner notification began april 21, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact nissan at 1-800-647-7261.
Suspension — RearCampaign 02V299000 · 12 Nov 2002Problem: On certain pickup trucks and sport utility vehicles, water may enter the rear axle housing due to inadequate sealing of the anti-lock braking system (abs) sensor.
Risk: This can result in corrosion and eventual failure of the wheel bearing. If this occurs, the wheel assembly could separate from the vehicle increasing the risk of a crash.
Remedy: Dealers will inspect the rear axle for water intrusion and any affected components will be replaced. The abs sensor will be resealed to prevent water intrusion. Owner notification began december 10, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact nissan at 1-800-647-7261.
Vehicle speed controlCampaign 02V298000 · 12 Nov 2002Problem: On certain pickup trucks and sport utility vehicles equipped with a supercharger, under certain conditions, such as full throttle in low gear when the engine is not fully warmed up and at cold ambient temperature, the amount of intake air flow through the air flow meter may exceed the maximum preset diagnosis limit value.
Risk: This will cause the engine control system to go into the failsafe mode. Under this condition, the malfunction indicator lamp will illuminate and engine speed will not exceed 2400 rpm regardless of the throttle position, increasing the risk of a crash.
Remedy: Dealers will reprogram the electronic control module. Owner notification began january 15, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact nissan at 1-800-647-7261.